Dropwise condensation—The effect of thermal properties of the condenser material
1973; Elsevier BV; Volume: 16; Issue: 2 Linguagem: Inglês
10.1016/0017-9310(73)90072-0
ISSN1879-2189
Autores Tópico(s)Electrohydrodynamics and Fluid Dynamics
ResumoThere exists conflicting evidence for the effect of the thermal properties of the condensing surface on heat-transfer during dropwise condensation of steam. In order to help to settle this issue. further precise measurements have been made using vertical copper and mild steel condensing plates, both of which were copper-plated to ensure identical surface conditions. The thickness of the copper plating was 0.012 mm for both plates. Dioctadecyl disulphide was used as promoter. Several tests were carried out at near-atmospheric pressure on different days using each plate in turn. Consistent results were obtained. The results for the two plates did not differ significantly and were in good agreement with earlier measurements for dioctadecyl disulphide-promoted vertical copper surfaces. Il existe des contradictions sur l'effet des propriétés thermiques de la surface de condensation sur le transfert thermique pendant la condensation en gouttes de la vapeur. Afin d'aider cette étude, des mesures précises ont été faites à l'aide de plaques verticales en cuivre et en acier doux, deux d'entre elles étant cuivrées pour réaliser des conditions superficielles identiques. L'épaisseur du recouvrement de cuivre est de 0, 012 mm pour les deux plaques. On a utilisé comme promoteur le disulfure de dioctadécane. On a mené sur plusieurs jours des essais à une pression proche de l'atmosphère en utilisant une plaque après l'autre. On a obtenu des résultats valables. Les résultats pour les deux plaques ne diffèrent pas de façon significative et sont en bon accord avec des mesures antérieures pour des surfaces verticales en cuivre et le disulfure de dioctadécane. Über den Einfluss der thermischen Stoffwerte der Kondensatoroberfläche beim Wärmeübergang durch Tropfenkondensation bestehen widersprüchliche Aussagen. Um diese Widersprüche beizulegen, wurden weitere genaue Messungen angestellt, und zwar mit senkrechten Kondensatorplatten aus Kupfer und unlegiertem Stahl. Beide Platten waren verkupfert, um gleiche Oberflächenbedingungen zu haben. Die Dicke der aufgetragenen Kupferschicht betrug 0.012 mm bei beiden Platten. Als Promoter wurde Dioktadecyl-Disulfid verwendet. Mehrere Versuche wurden bei etwa Atmosphärendruck durchgeführt, und zwar an verschiedenen Tagen, wobei die Platten abwechselnd benutzt wurden. Die erzielten Ergebnisse waren konsistent. Die Ergebnisse für beide Platten wichen nicht wesentlich voneinander ab und stimmten gut mit früheren Messungen an senkrechten Kupferoberflächen, die mit Dioktadecyl-Disulfid aktiviert waren, überein. Cy;щe;c;твыют нpo;тивo;pe;чнвьe; дa;нныe; нo; влнянию тe;нлo;выч c;вo;йc;твкo;ндe;нc;иpy;ющe;й иo;вe;pчнo;c;ти нa; тe;илo;нe;pe;нo;c; нpи кa;нe;льнo;й кo;ндe;нc;a;ции пa;pa;. Для выяc;нe;ния этo;гo; вo;нpo;c;a; пpo;пo;дилнc;ь тo;чныe; нзмpe;ния c; пo;мo;щью вe;pтикa;льныч кo;ндe;нe;нpy;ющич илa;c;тии из мe;ди и мa;лo;y;глe;po;диe;тo;й c;тa;ли. Oбe; плa;c;тины были o;мe;днe;ны для o;бe;c;пe;чe;ния o;дннa;кo;ьыч y;c;лo;ьий нa; нo;нe;pчнo;c;ти. To;лщпнa; мe;днo;гo; нo;кpытня кa;ждo;й плa;c;тины c;o;c;тa;влялa; 0,012 мм. B кa;чe;c;твe; a;ктивa;тo;pa; нc;нo;льзo;вa;лc;я двy;c;e;pниc;тый диo;ктa;дe;цил. He;c;кo;лькo; экe;иe;pимe;нтo;в. пpo;вo;дплo;c;ь пpи o;кo;лo; a;тмo;c;фe;pнo;м дa;влe;нии c; иc;нo;льзo;вa;ниe;м кa;ждьй дe;нь pa;зныч плa;c;тин пo;o;чe;pe;днo;. Pe;зy;льтa;ты для двy;ч нлa;c;тин знa;читe;льнo; иe; o;тличa;юo;тc;я п чo;po;шo; c;o;глa;y;ютc;я c; дa;нными нзмe;pe;ний для вe;pтнькa;лъныч мдныч нo;вe;pчнo;c;тe;й c; двy;c;e;pпиc;тым диo;ктa;дe;цилo;м, взятым в кa;чe;c;твe; a;ктивa;тo;pa;.
Referência(s)